List of Toyota D4D Probems (Choking, Hard Starting, etc.)

[desert fox]

txs sir,twice na kasi biglang namatay engine ko from a complete stop, i dont know kung may problem sa gas float or may tubig na tangke ko,i went to denso banawe and sabi ng technician dun after running the diagnostic tool ok naman daw though recommend nya palitan na supply pump ko,at present maintain ko half tank and so far hindi na naulit, ill try na rin siguro replace and drain my tank, pag ganun pa rin drop by na ko central diesel, thanks

baka ang ibig sabihin ng mekaniko mo na supply pump ay yung feedpump na nga....

[ward_23]

May mga problems pa din ba sa D4D? since 2005 pa ito ah,

Hindi pa ba naayos ng toyota sa mga 2010 models nila?

[ben_david19]

Top seller pa din naman daw,kaya no probs???

hahaha amen bro. tutal marami pa rin naman na let us say walang alam sa cars na ang pagkakaalam nila ang Toyota ay bulletproof that is why ito pa rin ang bibilhin nila.

sa ngayon alangan na ang reliability ng Toyota, although sabihin natin na kunwari yung D4D issues na out 10 Innovas, 1 out 10 lang ang may D4D issue, I won't and will never gamble these kind of things.

eh mabuti pa yung mga taxi umaandar samantalang ikaw ito, almost bago ang sasakyan inuubo na.

[prinx_09]

basta ang malinaw, laging hindi affected ang pilipinas sa toyota recalls. laging good quality kapag yung mga units e naibenta sa pinas heheh
D4D problems? Toyota Philippines is not doing anything or even admitting these issues. Talaga bang mahina ang toyota sa diesel engines? if you are beyond the warranty period, buy the parts that need to be replaced na lang. ganon na lang ba ang solution? then blame it sa dirty diesel? sad

[shibby75]

why risk your million peso on a D4D when you have the option to go for gas?


Di lang toyota nagkakaproblema jan, pati na montero sport which sells like hot cakes!

[desert fox]

hahaha amen bro. tutal marami pa rin naman na let us say walang alam sa cars na ang pagkakaalam nila ang Toyota ay bulletproof that is why ito pa rin ang bibilhin nila.

sa ngayon alangan na ang reliability ng Toyota, although sabihin natin na kunwari yung D4D issues na out 10 Innovas, 1 out 10 lang ang may D4D issue, I won't and will never gamble these kind of things.

eh mabuti pa yung mga taxi umaandar samantalang ikaw ito, almost bago ang sasakyan inuubo na.

kasi bro, noong araw pa kasi itong brand na ito Toyota, panahon pa ng mga lolo natin, toyota na yan.....lalo na mga taxi noon....

Avalon,Fortuner,Corolla...ilan lang ito mga sasakyan naaksidente dito walang kabungguan....alam nyo naman dito,news black out....

sun and the beach....

[dbhollanda]

why risk your million peso on a D4D when you have the option to go for gas?


Di lang toyota nagkakaproblema jan, pati na montero sport which sells like hot cakes!

true kung gusto talaga toyota fort e di gas na lang yun lang dahil medyo malakas sa FC yan but then alang prob na tulad ng D4D. or kung gusto naman ng diesel talaga e di punta na lang sa ibang brand na walang problema sa dumi ng diesel dito sa atin.

[SRGuy]

Pati ba ang mga new innova diesel may problema pa din hanggang ngayon?

[brethren101]

I was also considering buying an Innova, but after reading the seemingly endless woes on the D4D engine, I'm now looking for other alternatives. However the Toyota SA I was talking to recently advised me that Toyota has changed its fuel injector on on the D4D, but the SA cant elaborate on the injectors source. Any body else heard about this?

[weisshorn]

I was also considering buying an Innova, but after reading the seemingly endless woes on the D4D engine, I'm now looking for other alternatives. However the Toyota SA I was talking to recently advised me that Toyota has changed its fuel injector on on the D4D, but the SA cant elaborate on the injectors source. Any body else heard about this?

hmmnn.. mukhang binobola ka ng SA na ito. Bakit fuel injectors ang papalitan eh fuel pump ang defective. it seems that your SA is not familiar with the problem bugging the d4d engine.

Just my thought, Peace..

[Blackshark1999]

Has anyone experienced this?

3 days ago it rained hard in QC. At Amoranto water was more or less 4" deep. I drove my Innova through this 4" flood taking care not to over splash. Its only a 25 meters stretch. Now after a few minutes, my Innova started to hesitate at first gear. The engine did not stop, but the car jerked because of hesitation. Then it drove fine.

The following day, same problem presented itself once into my 15km ride to the office.

Today I parked with my engine on for 10 mins. When I started to drive, the Innova choked, hesitated then the engine stopped. I had to re-start in the middle of Quezon Avenue. After that all is well again.

So the problem started when I drove my Innova in a flooded street. What could be the cause?

I drive a 2008 Innova D4D E Manual. Odo 26,700+.

Any ideas guys.

[oaanwatchgolf]

I am really close in jumping to a D4D engine -- it's the Hilux G 4x2; clean na po ba ito? Taga province kasi ako at malayo sa casa kaya I am making sure..

[dr. d]

Has anyone experienced this?

3 days ago it rained hard in QC. At Amoranto water was more or less 4" deep. I drove my Innova through this 4" flood taking care not to over splash. Its only a 25 meters stretch. Now after a few minutes, my Innova started to hesitate at first gear. The engine did not stop, but the car jerked because of hesitation. Then it drove fine.

The following day, same problem presented itself once into my 15km ride to the office.

Today I parked with my engine on for 10 mins. When I started to drive, the Innova choked, hesitated then the engine stopped. I had to re-start in the middle of Quezon Avenue. After that all is well again.

So the problem started when I drove my Innova in a flooded street. What could be the cause?

I drive a 2008 Innova D4D E Manual. Odo 26,700+.

Any ideas guys.

think back: where did you have a gas fill-up last? is it possible, some water got into your fuel?

[jhayster14]

good day mga sir..
kumuha kami ng Toyota Hiace Commuter, 1 month palang ung van and gagamitin sana pamasada. unang plano namin is, kumuha ng nissan urvan dahil nga mas mura at kadalasan, un ang ginagamit pamasada. pero narinig ko sa ibang urvan owners na underpowered daw ito van lalo na kung puno (eg 18 pax) kaya we plan to buy the new Toyota Hiace para un nalang ipamasada.

mga sir, ask ko sana kung meron na bang problem regarding sa van na hiace na ginamit na pamasada? regarding sa D4D problem? kasi 1 month palang ung van and cross fingers ako na sana wala pang maging problem ung van, in 5 years. pero ung tinanong namin ung SA sabi samin, bagong upgrade daw ung Computer Box sa lahat ng variant.

sa tingin niyo mga sir? wala na kaya magiging problema un? in Choking? Hard Starting? i hope na sana wala na maging problem ung van. laki pa naman ng gastos.

[timo07]

Has anyone experienced this?

3 days ago it rained hard in QC. At Amoranto water was more or less 4" deep. I drove my Innova through this 4" flood taking care not to over splash. Its only a 25 meters stretch. Now after a few minutes, my Innova started to hesitate at first gear. The engine did not stop, but the car jerked because of hesitation. Then it drove fine.

The following day, same problem presented itself once into my 15km ride to the office.

Today I parked with my engine on for 10 mins. When I started to drive, the Innova choked, hesitated then the engine stopped. I had to re-start in the middle of Quezon Avenue. After that all is well again.

So the problem started when I drove my Innova in a flooded street. What could be the cause?

I drive a 2008 Innova D4D E Manual. Odo 26,700+.

Any ideas guys.

A 4 inch deep water should not cause even a minor issue. Baka sa iba nagoriginate ang problem mo such as Dr. D's response.

[myas110]

look at the other thread na love nya ang kanyang hiace d4d, no problems according to the owner.

[renzo_d10]

Has anyone experienced this?

3 days ago it rained hard in QC. At Amoranto water was more or less 4" deep. I drove my Innova through this 4" flood taking care not to over splash. Its only a 25 meters stretch. Now after a few minutes, my Innova started to hesitate at first gear. The engine did not stop, but the car jerked because of hesitation. Then it drove fine.

The following day, same problem presented itself once into my 15km ride to the office.

Today I parked with my engine on for 10 mins. When I started to drive, the Innova choked, hesitated then the engine stopped. I had to re-start in the middle of Quezon Avenue. After that all is well again.

So the problem started when I drove my Innova in a flooded street. What could be the cause?

I drive a 2008 Innova D4D E Manual. Odo 26,700+.

Any ideas guys.

4 inch floods are fairly low. Should not cause any side effects on the engine.

Probably it's just a coincidence that the choking happened after you drove onto the flood or most likely, the gas that you filled up is contaminated with water.

[ptk675]

i guess my question now is (and more directed towards D4D owners) knowing what you know now about the D4D problems, would you still buy a D4D equipped innova/hiace/hilux/fortuner or would you go gas, or another make altogether?

[myas110]

^ pero sabi daw ng ilan, ok na yung mga d4d equipped vehicles especially yung mga new released ones. i don't know. or swertehan lang ang pagkuha ng d4d na walang problema sa choking na yan.

[ecozone]

share ko lang, my sister got a brand new D4D Fortuner last may, everyday used, so far wala pa naman naging problema like choking and hard starting. ang comment lang matagtag pag walang load pero smooth na pag meron. gamit namin yesterday punta batangas, ang ganda ng takbo...