Mitsubishi Pajero Fieldmaster (Gen 2.5) [ARCHIVED]

[promdiboy]

Paj-man, imho as long as tumutulo siya i guess ok siya, you need to remove the carpet as well, it took me two nights para mapatuyo siya , iniwan ko electric fan sa loob overnight, habang sampay yung foam sa sahig ng passenger, yung foam sa gitna (transmission) makapal, and ito pa magpapasama diyan may amoy yung tubig kasi, underneath the passenger floor is the muffler. it gets hot kaya may amoy nakulob na tubig. and diyan din ang intake ng aircon, kaya for sure kakalat yung amoy,

[pajerokid]

Hi Guys,

meron na palang Pajman sa Mymitsuph....hav to pic a dif name.

Advise naman uli mga gurus... i notice sa front passenger floor may basa (wet) underneath the carpet. I check it out and had it dried. Initially i thought the problem was water was entering in the rubber drain plug so i place sealant on the sides and the whole rubber. unfortunately, yesterday, i notice mediyo basa uli yng carpet. could the the wetness is coming from the aircon (evaporator -- baka barado) pero d naman basa yng carpet lapit sa evaporator???? where is the water coming from???? help naman..

btw, here is another link that you could download -- its a pdf workshop manual of a Pajero Sport - pwede na rin pang guide for some checking and troubleshooting.

PK, baka pwede ma xerox naman yung repair manual... hehehe

Salamat.

Nice guide! Particularly the 4D5 engine section this should be useful for a lot of peeps. The leak is definitely coming from one place.... the evaporator. your drain hose might be clogged or not put back in place (in case repaired).

Ok lang sana ipa-xerox yung repair manuals, kaso bibigay na yung libro pag pina-photocopy since its quite old

[pajerokid]

Pk baka di pa natuyo masyado silicon kaya natanggal, did you get oem na gasket? how much inabot?

Mura lang PB yung valve cover gasket. 700 orig. half moons are 80 each, pero iba sukat ng front and rear. Tomorrow baka fuel filter palitan ko.... no probs naman so far pero hindi pa ako nagpapalit since i got the vehicle hehehe.

[pajerokid]

PB,

Many thanks for the advise, i was planning pa naman to pull out the drain hose. Buti na lng. Is there a way for me to check baka barado lng yng drain hose ko without pulling out the evaporator? Ok kase yng lamig ng aircon ko.

Salamat uli.

You can try sticking a stick into the tube from the engine side.... or a straw. this would definitely loosen up any clog if there is any. i experienced this before... water was trickling on my foot whenever cornering... yun pala the thing was filled with water nga because of clogged dirt. nung tinuhog ko ng tingting, mud gushed out then ok na.

[vanquish]

Whats the reasonable price for a 2005 model pajero? Tnx

[AC]

mga bossing pajero peeps.. patulong naman po sana ako.. regarding sa problem ko sa signal stalk ng pajero..

i already have a thread sa... workshop about it... mag isa nagbrbright yung.. headlights ko.. lalo na pag nalulubak.. loose po yata yung stalk ng signal.. hindi na.. siya nagbrbright when i push the stalk... kayalang.. hirap magdrive while pushing stalk.. hehe

thanks

http://tsikot.yehey.com/forums/showthread.php?t=45374

[Paj-Man]

Guys,

Problem solve doon sa leak ko. Culprit is the drain hose. hindi pala nakakabit mabuti. You can pull that drain hose from the outsite.

PK, PB and Joseph many thanks again.

[Paj-Man]

Guys,

Question lng.
I notice today that mediyo bumaba yung idling ko pag naka drive (and stepping on the brakes). Before kase pag nasa neutral or nasa drive (stepping on the brakes) my rev is around 850-900.

Ngayon pag neutral nasa 850-900, but if naka drive (stepping on the brakes) nasa 750. At mediyo nararamdaman ko ang nginig ng makina.

Is this normal?

Appreciate any feedback.

Salamat.

[promdiboy]

Guys,

Problem solve doon sa leak ko. Culprit is the drain hose. hindi pala nakakabit mabuti. You can pull that drain hose from the outsite.

PK, PB and Joseph many thanks again.

nice to hear ok na problem mo, buti nailbalik mo yung drain hose, ang hirap ipasok sa loob ng wall yung drain hose, nakabuka diba? di ko nga maibalik ng maiigi, hintay ko nalang next aircon cleaning. pahingi naman ng tips paano ipasok yung nakabukang side

[Paj-Man]

PB,

Actually last Sat i went to Joseph to have my Pajero chk (lalo na yng mga supports sa ilalim). For the drain hose, it was him who fix the problem, but of cors, pinanuod ko para nxt time, i already know what and how to do it. Anyway, may potruding na aluminum pipe about 1 inch sa labas. we applied sealant and tie wrap the hose para d lumuwang. So far effective sya.

Btw, ok pala doon kila Joseph, alam nya talaga ins and outs of a pajero. buti na lng malapit sa amin. hehehe

[pajerokid]

mga bossing pajero peeps.. patulong naman po sana ako.. regarding sa problem ko sa signal stalk ng pajero..

i already have a thread sa... workshop about it... mag isa nagbrbright yung.. headlights ko.. lalo na pag nalulubak.. loose po yata yung stalk ng signal.. hindi na.. siya nagbrbright when i push the stalk... kayalang.. hirap magdrive while pushing stalk.. hehe

thanks

http://tsikot.yehey.com/forums/showthread.php?t=45374

Palitan mo na lang kaya yung steering switches?

[pajerokid]

nice to hear ok na problem mo, buti nailbalik mo yung drain hose, ang hirap ipasok sa loob ng wall yung drain hose, nakabuka diba? di ko nga maibalik ng maiigi, hintay ko nalang next aircon cleaning. pahingi naman ng tips paano ipasok yung nakabukang side

hmmm, medyo mahirap nga ibalik from the outside iyon hehe.

[promdiboy]

thanks peeps. naka cable tie din yung drain hose ko in 2 places, i guess kailangan talaga tiyaga para maipasok yun.
paj-man di kaya di mo na maalis yung drain hose pag silicon ang ginamit na pang seal? i used butyl para maalis ko parin pag dating ng aircon cleaning,

pajero peeps, want to improve the sound of your speakers (vocals mas lilinis not louder)? without buying any equipment? if you have seps sa harap mas noticable ang igaganda, just cut the plastic part that covers the rear of your door speakers. dapat kasi open yung likod para di bumabalik sa harap yung sound sa likod ng speaker (backwave) kaya nagiging parang nasa cave yung kumakanta. imho lang to peeps, subjective kasi.

[AC]

Palitan mo na lang kaya yung steering switches?

sir.. hindi po siya ordinary switch eh.. its the stalk.. more than 10t pesos po ang assembly ng ganun.. hehe

[CargoBoy]

Guys,

Question lng.
I notice today that mediyo bumaba yung idling ko pag naka drive (and stepping on the brakes). Before kase pag nasa neutral or nasa drive (stepping on the brakes) my rev is around 850-900.

Ngayon pag neutral nasa 850-900, but if naka drive (stepping on the brakes) nasa 750. At mediyo nararamdaman ko ang nginig ng makina.

Is this normal?

Appreciate any feedback.

Salamat.

Paj-Man - Try to lift your ride to check the condition of transmission support. If the support has sign of crack then i advise for immediate replacement as this causes transmission to vibrate a lotespecially when tranny is engage (D-mode) while pressing the brake hard. I experienced the same too (low rpm) with strong vibration before i replaced the support. Part is 3200pesos (OEM) and labor is 600pesos. Hope this helps.

[CargoBoy]

pajero peeps, want to improve the sound of your speakers (vocals mas lilinis not louder)? without buying any equipment? if you have seps sa harap mas noticable ang igaganda, just cut the plastic part that covers the rear of your door speakers. dapat kasi open yung likod para di bumabalik sa harap yung sound sa likod ng speaker (backwave) kaya nagiging parang nasa cave yung kumakanta. imho lang to peeps, subjective kasi.

PB - If you want to maximize the sound quality of your front door speaker you may want to deaden the door. This will make the wall solid which make the sound as if coming from sealed box (deep and detailed). I used flashband material and it cost me around 600pesos for two doors.

[CargoBoy]

CB, ok lang yun, curious lang ako saan yung support,

any peanut bulb base will do, its the same bulb as our side markers, It would be better kung 180 degree yung angle ng leds na makuha mo. yung para sa 200 kph na led meron pa ako isa. ito kasi yung socket type na hindi common yung socket, pwede ko padala sayo,

CB - di ko pa maasikaso yun front diff support pic just arrived yesterday from offshore assignment.
Thanks by the way for your generosity on 200kph bulb. Will send you PM.

[AC]

just had my gen2 calibrated kanina.. sounds like new again... hehe...

sa thursday.. going to have my timing belts replaced..

does anyone here know what are the codes? Im going to be using mitsuboshi timing belts.. both yung malaki and maliit.. thanks

[Paj-Man]

CB,

Many thanks for the advise. Will take a look at my transmission support.

Salamat.

[dcarin14]

Thanks very very much sir PK for that info Kaya lang talagang very rare nga po ang M/T local 2.5 Gen.

I bought my G2.5 pajero Sept last year. It's a M/T 99. I really want a manual tranny and it took me two years to find one na may makakasabay na credit card to offer a cash loan and meet my budget. It happens pa on my birthday.

Played Santa to kids from squatters area from our town last year and hauled 11 kids to Mall of Asia. (you should have heard these kids singing while we were crusiing from Rizal to Manila, wala panama ang Vienna Boys Choire) I am very satisfied with my Pajero. Drove it to Baguio with my daughter + school friends, my son and my wife. Sisiw ang Kennon road. So far I have no major problem encountered except sa blinking sa 4x4 display. I have this temporarily resolved following the threads on another forum; similar din sa narito.

I am running my Paj at 8-10km/li. Anyway, di naman ako maratrat. Change oil practice ko is 4000 then 5000 then 4000 sequence, same as with my other cars.

After reading the Post #1 yesterday and completed this today. I learned a lot - really very informative. I wonder whether these gurus we have here can work in our gov't and help solved our problems..

More power to all of you here. Keep on posting