'96 NJ Pajero: 3.5V6 to DiD conversion... feasible?

[MockTurtle]

been pondering this for a bit now.

suppose anything is possible. replace my current 3.5 V6 6G74 engine with a diesel unit - either a 2.8 or preferably a 3.2 DiD? its gonna be a hell of a job. think wiring, engine management, transmission etc... is this path worth it?

i think i'm at the point where its rebuild/overhaul vs full conversion. i'm leaning towards diesel coz well, this thing can chow juice!

Otherwise perhaps sell the Pajero and get a diesel Land Cruiser...

thoughts anyone?

[larshell]

Ive seen 6G72 change to 4D56 TDIC. They change the engine together with the tranny and no conversion made except for the transmission support they move it a couple inch.No problem with the wiring and the fuel line no major alteration.

6G74, I think is another story coz it is a GDI engine and it is bigger than 6G72 but I think it can be done.

Just in case you want to sell your Pajero I'm interested.

BTW 4M40 cost around 100K to 120K with the tranny surplus japan.

[niky]

How far will you drive it?

THe problem with an old surplus conversion is that you're never sure of the condition of the engine you're putting in. Doing it with a newer DiD is a safer bet, but the expense will not be offset by lower gas bills.

Wanna try LPG?

[drey]

wow... a nice engine convesion... the 3.2 DiD... Why not consider the 4D56 DiD... I think it is a much cheaper engine.

[MockTurtle]

tell me more about the 4D56? is that the 2.8?

i'm just scheming at the moment. depends on what i find available at the breakers, at this point overhaul is most probable.

anyways i intend to keep the vehicle for a while... hence the question with slapping in a newer engine. i use the pajero solely for trekking/camping/fishing trips so.. just wishing i was back home - iba talaga ang mekanik na pinoy. mabilis pa makahanap ng parts. mitsu parts/techies are hard to come by and expensive in africa

[drey]

The 4D56 is the 2.5L engine seen on the L300. Pero meron na pong bagong 2.5L CRDi whichi is more powerful than the 2.8L 4M40 Pajero engine.

Pwede naman ata i-LPG conversion mo sir. Mas better po yun and its still a V6. You can try searching for class A LPG equipment in Europe via the net or in Africa.